TSB Lists for 05-07 Mustang GT 4.6L.

[DynoJoe]

Technical Service Bulletins
2005 MUSTANG - US (English)


05-10-19
INTERMITTENT CD PLAYER CONCERNS - AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS

05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

05-9-15
MIL AND ETC LAMPS ON WITH BOTH DTC P2106 AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR

05-9-14
CONVERTIBLE TOP RAISE/LOWER INSTRUCTIONS

05-9-11
FRONT SUSPENSION POPPING NOISE WHILE TURNING RIGHT OR LEFT - VEHICLES BUILT BEFORE 4/8/2005

05-9-3
INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

05-8-8
GROWL/GRINDING NOISE IN 2ND OR 3RD GEAR DURING DECELERATION - TR3650 MANUAL TRANSMISSION - VEHICLES BUILT BEFORE 1/15/2005

05-8-6
EXHAUST VIBRATION AT 850 RPM - 4.0L ENGINE AND AUTOMATIC TRANSMISSION

05-7-3
AXLE WHINE - VEHICLES BUILT THROUGH 11/15/2004

05-6-15
AIR BAG WARNING LAMP ON - DTC B1891 IN RESTRAINTS CONTROL MODULE OR LAMP FLASHES CODE 53 - VEHICLES BUILT BEFORE 10/02/2004

05-4-8
FUEL FILL SLOW, OR DIFFICULT TO FILL

05-3-1
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

04-26-22
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) P035X AND NO DRIVEABILITY SYMPTOMS - 4.6L 3V ENGINE

04-26-16
WELD BONDING PROCEDURE

04-24-20
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS

04-24-14
GENERAL PCM PROGRAMMING PROCEDURES

04-24-5
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR

04-16-1
ENGINE MISFIRE OR ROUGH RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS

04-14-7
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

04-9-6
BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION


I will update this more this afternoon.

 

[Casper98gt]

2005 Mustang TSB's

Technical Service Bulletins
2005 MUSTANG - US (English) UPDATED: 6-15-06
06-14-3
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-12-11
LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-10-13
MIL P0463 OR ERRATIC FUEL GAUGE

06-10-10
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-10-1
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-9-9
HESITATION ON ACCELERATION AFTER LONG CRUISE

06-7-10
MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V

06-5-4
PARK BRAKE CABLE FREEZING/REAR BRAKES DRAGGING

06-4-9
A/C COMPRESSOR NOT OPERATIONAL / LOW FREON - SHAFT SEAL LEAKS

06-4-7
TICKING AND/OR KNOCKING NOISE FROM ENGINE - 4.6L/5.4L 3V

06-4-2
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

06-4-1
RATTLE/NOISE FROM THE CENTER STACK (RADIO/HEATER) OF THE INSTRUMENT PANEL OR GEARSHIFT AREA

06-3-13
FUEL FILL SLOW, OR DIFFICULT TO FILL

06-2-9
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V

05-24-6
CONVERTIBLE SYSTEM CONCERNS

05-22-8
WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING

05-21-2
LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

05-20-2
REAR AXLE NOISE
05-19-10
LOOSE SEAT CUSHION COVER TRIM ON FRONT OF FRONT SEAT

05-18-10
BRAKE NOISE - VEHICLES BUILT BEFORE 3/8/2005
05-16-12
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS
05-15-13
FRONT SIDE MARKER LAMP RETAINING TAB BREAKING
05-15-12
FUEL FILL SLOW, OR DIFFICULT TO FILL - VEHICLES BUILT BEFORE
4/26/2005
05-15-8
TICKING AND/OR KNOCKING NOISE FROM ENGINE - 4.6L/5.4L 3V
05-15-2
GROWL/GRINDING NOISE IN 2ND OR 3RD GEAR DURING DECELERATION - TR3650 MANUAL TRANSMISSION - VEHICLES BUILT BEFORE 2/21/2005
05-14-4
WRENCH LIGHT ON WITH BOTH DTC P2106 AND P2135 - VEHICLES BUILT 11/29/2004 AND PRIOR
05-10-19
INTERMITTENT CD PLAYER CONCERNS - AUDIO UNIT PROGRAMMABLE MODULE INSTALLATION (PMI) REQUIREMENTS
05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

05-9-14
CONVERTIBLE TOP RAISE/LOWER INSTRUCTIONS
05-9-11
FRONT SUSPENSION POPPING NOISE WHILE TURNING RIGHT OR LEFT - VEHICLES BUILT BEFORE 4/8/2005
05-9-3
INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

05-8-6
EXHAUST VIBRATION AT 850 RPM - 4.0L ENGINE AND AUTOMATIC TRANSMISSION
05-7-3
AXLE WHINE - VEHICLES BUILT THROUGH 11/15/2004

05-6-15
AIR BAG WARNING LAMP ON - DTC B1891 IN RESTRAINTS CONTROL MODULE OR LAMP FLASHES CODE 53 - VEHICLES BUILT BEFORE 10/02/2004
05-3-1
MAF DIAGNOSTIC SERVICE TIP - VEHICLES EQUIPPED WITH EGR SYSTEM MODULE (ESM)

04-26-22
MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH MULTIPLE DIAGNOSTIC TROUBLE CODES (DTCS) P035X AND NO DRIVEABILITY SYMPTOMS - 4.6L 3V ENGINE
04-26-16
WELD BONDING PROCEDURE
04-24-20
LIMITED SLIP AXLE CHATTER, SHUDDER, BINDING SENSATION, OR VIBRATION DURING LOW SPEED TURNING MANEUVERS

04-24-14
GENERAL PCM PROGRAMMING PROCEDURES

04-24-5
REAR WINDOW DEFROSTER GRID/INTEGRAL ANTENNA DIAGNOSIS AND REPAIR - TERMINAL TAB REPAIR
04-16-1
ENGINE MISFIRE OR ROUGH RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS
04-9-6
BODY - PAINT - IRON PARTICLE REMOVAL - INDUSTRIAL FALLOUT - ACID RAIN NEUTRALIZATION

 

[Casper98gt]

2006 Mustang TSB's

Technical Service Bulletins
2006 MUSTANG UPDATED: 3-17-07

07-5-13
DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE

07-5-8
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

07-4-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE

07-3-9
MIL ON - DTC P0456

07-1-7
MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

06-26-2
CARPET REMOVE AND REPLACE

06-26-1
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

06-25-15
ALUMINUM BODY PANELS - CORROSION - SERVICE TIP

06-22-18
POWER WINDOW DIAGNOSIS

06-22-16
CONVERTIBLE TOP WEAR - BUILT BEFORE 10/11/2006

06-21-19
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

06-21-7
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-19-12
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V

06-19-2
8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-18-16
IDENTIFYING THE CORRECT REPLACEMENT HEAD GASKET FOR CERTAIN REMANUFACTURED ENGINES - SERVICE TIP

06-17-8
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

06-15-8
KEYPAD DIAGNOSTICS - DEALER INSTALLED ACCESSORY

06-14-3
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-12-11
LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-10-13
MIL P0463 OR ERRATIC FUEL GAUGE

06-10-10
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-10-5
5R55S - TRANSMISSION FLUID LEAK

06-10-1
AIR CONDITIONER COMPRESSOR CLUTCH FAILURE - REVISED COMPRESSOR CLUTCH

06-9-11
LOUD TICKING NOISE - 3-VALVE ENGINES - STUCK LASH ADJUSTER

06-9-9
HESITATION ON ACCELERATION AFTER LONG CRUISE

06-7-10
MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V

06-5-4
PARK BRAKE CABLE FREEZING/REAR BRAKES DRAGGING

06-4-2
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

06-4-1
RATTLE/NOISE FROM THE CENTER STACK (RADIO/HEATER) OF THE INSTRUMENT PANEL OR GEARSHIFT AREA

06-3-13
FUEL FILL SLOW, OR DIFFICULT TO FILL

06-2-9
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V

06-1-5
DTC P1000 MAY NOT CLEAR IN HIGH ALTITUDE CONDITIONS

05-24-6
CONVERTIBLE SYSTEM CONCERNS

05-22-8
WDS COP KIT DIAGNOSTIC TIPS - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING

05-20-2
REAR AXLE NOISE

05-18-7
WIRING - SOLDERING AND CRIMPING REPAIRS - SERVICE TIPS

05-16-12
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

05-9-18
DISCHARGED BATTERY - CHARGING SERVICE TIPS

05-9-3
INTERIOR PLASTIC TRIM - PAINT-TO-MATCH AND REPAIR - INTERIOR SPRAY PAINT AND ADHESION PROMOTER USAGE INSTRUCTIONS

 

[Casper98gt]

2007 Mustang TSB's

Technical Service Bulletins
2007 MUSTANG UPDATED: 3-17-07

07-6-7
SPOILER/DECK LID CONTACT

07-5-13
DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE

07-5-8
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS

07-4-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE

07-1-7
MERCON® ATF REPLACED BY MERCON® V AS A SERVICE FLUID FOR SOME POWER STEERING SYSTEMS

06-26-2
CARPET REMOVE AND REPLACE

06-26-1
MERCON ATF IS BEING REPLACED BY MERCON V AS A SERVICE FLUID FOR SOME MANUAL TRANSMISSIONS

06-25-15
ALUMINUM BODY PANELS - CORROSION - SERVICE TIP

06-25-3
PIONEER NAVIGATION RADIO - SEEK FUNCTION INOPERATIVE - SERVICE TIP

06-22-18
POWER WINDOW DIAGNOSIS

06-22-16
CONVERTIBLE TOP WEAR - BUILT BEFORE 10/11/2006

06-21-19
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)

06-21-7
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES

06-19-2
8.8 LIMITED SLIP AXLE MOAN/GROAN NOISE DURING LOW SPEED TURNING MANEUVERS

06-17-8
SERVICE WIRING HARNESS REPLACEMENT GUIDELINES - SERVICE TIPS

 

[Casper98gt]

2005-2007 Ford Mustang TSB's ( Always updated )

Here are all 2005, 2006 and 2007 Ford Mustang TSB's.


2005 Ford Mustang TSB's
2006 Ford Mustang TSB's
2007 Ford Mustang TSB's

Something like this, now you can make this a sticky and then when someone wants to check out TSB's they can just click this sticky and find all their needs.

Feel free to edit this as you need to.

Casper

 

[Hawgman]

04-9-6
Body - Paint - Iron Particle Removal - Industrial Fallout - Acid Rain Neutralization

 

[Hawgman]

04-14-7
Service Wiring Harness Replacement Guidelines - Service Tips

 

[Hawgman]

04-16-1
Engine Misfire Or Rough Running - Coil On Plug (cop) Ignition Systems - Wds Cop Kit Diagnostic Tips

 

[Hawgman]

04-24-5
Rear Window Defroster Grid/integral Antenna Diagnosis And Repair - Terminal Tab Repair

 

[Hawgman]

04-24-14
General Pcm Programming Procedures

 

[Hawgman]

04-24-20
Limited Slip Axle Chatter, Shudder, Binding Sensation, Or Vibration During Low Speed Turning Maneuvers

 

[Hawgman]

04-26-16
Weld Bonding Procedure

 

[Hawgman]

05-3-1
Maf Diagnostic Service Tip - Vehicles Equipped With Egr System Module (esm)

 

[Hawgman]

05-4-8
Fuel Fill Slow, Or Difficult To Fill

 

[Hawgman]

05-06-09
Intermittend CD Player Concerns

 

[Hawgman]

05-6-15
Air Bag Warning Lamp On - Dtc B1891 In Restraints Control Module Or Lamp Flashes Code 53 - Vehicles Built Before 10/02/2004

 

[Hawgman]

05-14-04
Wrench Light On With Both DTC P2106 And P2135 - Vehicles Built 11/29/2004 And Prior

 

[Hawgman]

05-7-3
Axle Whine - Vehicles Built Through 11/15/2004

 

[Hawgman]

05-8-6
Exhaust Vibration At 850 Rpm - 4.0l Engine And Automatic Transmission

 

[Hawgman]

05-8-8
Growl/grinding Noise In 2nd Or 3rd Gear During Deceleration - Tr3650 Manual Transmission - Vehicles Built Before 1/15/2005